Previously we reported that a mutant of Corynebacterium glutamicum ATCC14067 with reduced H⁺-ATPase activity, F172-8, showed an approximately two times higher specific rate of glucose consumption than the parent, but no glutamic acid productivity under the standard biotin-limited culture conditions, where biotin concentration was set at 5.5 μg/l in the production medium (Sekine et al., Appl. Microbiol. Biotechnol., 57, 534–540 (2001)). In this study, various culture conditions were tested to check the glutamic acid productivity of strain F172-8. The mutant was found to produce glutamic acid under exhaustive biotin limitation, where the biotin concentration of the medium was set at 2.5 μg/l with much smaller inoculum size. When strain F172-8 was cultured under the same biotin-limited conditions using a jar fermentor, 53.7 g/l of glutamic acid was produced from 100 g/l glucose, while the parent produced 34.9 g/l of glutamic acid in a medium with 5.5 μg/l biotin. The glutamic acid yield of strain F172-8 also increased under Tween 40-triggered production conditions (1.2-fold higher than the parent strain). The amounts of biotin-binding enzymes were investigated by Western blot analysis. As compared to the parent, the amount of pyruvate carboxylase was lower in the mutant; however, the amount of acetyl-CoA carboxylase did not significantly change under the glutamic acid production conditions. To the best of our knowledge, this is the first report showing that the H⁺-ATPase-defective mutant of C. glutamicum is useful in glutamic acid production.

This article cannot obtain the latest cited-by information.